Advertising:

Siemens MS43 PCB Components

From MS4X Wiki
The printable version is no longer supported and may have rendering errors. Please update your browser bookmarks and please use the default browser print function instead.

Front Side

Siemens MS43 PCB Front.png

1. Infineon C167CR-LM CPU

16-Bit Single-Chip Microcontroller C166 Family File:Infineon C167CR.pdf

Chip Markings
Infineon
SAK-C167CR-LM
GA-T

2. AMD AM29F400BB Flash

4 Megabit CMOS 5.0 Volt Boot Sector Flash Memory File:AMD AM29F400B.pdf

Chip Markings
AM29F400BB
-55SI
0047GBA N

3. ST M93C86 EEPROM

16 Kilobit Serial Access EEPROM File:ST M93C86.pdf

Chip Markings
93C86 6
K103M

4. Crystal

Generic 8.000000MHz Crystal

Chip Markings
8.000000
K 0041

5. IR 14CL40 IGBT

Ignition IGBTs with cylinder 6 at the top and cylinder 1 at the bottom. File:International Rectifier 14CL40.pdf

In later indexes these were labeled "Infineon BTS2140-1B" but they are the same components.

Chip Markings
14CL40
0 H4

6. TDK ZJY25 TVS Diode

CAN Bus ESD Protection TVS Diode

Chip Markings
TDK
ZJY25
Z

7. Ambient Pressure Sensor

Older MS43 indexes use a Motorola MPXAZ4115A pressure sensor, newer ones use an Infineon KP120 for altitude compensation

Motorola MPXAZ4115A

File:Motorola MPXAZ4115A.pdf

Chip Markings
MPXAZ4115A
50
K0107

Infineon KP120

File:Infineon KP120.pdf

8. Mitsubishi M37477M2 MCU

Single-Chip 8-bit CMOS Microcomputer File:Mitsubishi M37477M2.pdf

This additional MCU is part of the drive-by-wire system.

Chip Markings
SW.0ET32040
M37477M2T3907FP
107103

9. ON HC4851A Multiplexer

MS42/MS43 TIA Signal Diagram
MS42/MS43 TOIL Signal Diagram

Analog Multiplexer/Demultiplexer with Injection Current Effect Control File:ON MC74HC4851A.PDF

Chip Markings
SW.HC4851A
PEI110

Input Description

  • Pin 1 - EGT Sensor Pre-Cat Bank 1 (not equipped)
  • Pin 2 - Ignition Coil Variant Detection (Later Indexes)
  • Pin 4 - EGT Sensor Post-Cat Bank 2 (not equipped)
  • Pin 5 - EGT Sensor Pre-Cat Bank 2 (not equipped)
  • Pin 12 - Coolant Temperature Sensor (828Ohm Pullup Resistor)
  • Pin 14 - Intake Air Temperature Sensor (2.49kOhm Pullup Resistor)
  • Pin 15 - Oil Temperature Sensor (828Ohm Pullup Resistor)

10. ON HC4851A Multiplexer

Analog Multiplexer/Demultiplexer with Injection Current Effect Control File:ON MC74HC4851A.PDF

Chip Markings
SW.HC4851A
PEI110

Input Description

  • Pin 5 - Fuel Cap Status Switch (4.7KOhm Pullup Resistor)

11. ST ATM39B Octal Channel Low-Side Switch

A suitable 1:1 replacement seems to be the Intersil HIP0045 File:Intersil HIP0045.pdf

Chip Markings
ATM39B-556757
1992N0114
MALAYSIA

Pin Description

  • Pin 4 -
  • Pin 5 - X60003.45 - Thermostat
  • Pin 6 -
  • Pin 7 - X60003.3 - Spare Output 1
  • Pin 14 -
  • Pin 15 - X60003.45 - Thermostat
  • Pin 16 - X60003.49 - DISA Valve
  • Pin 17 -

12. ST ATM39B Octal Channel Low-Side Switch

A suitable 1:1 replacement seems to be the Intersil HIP0045 File:Intersil HIP0045.pdf

Chip Markings
ATM39B-556757
1992N0114
MALAYSIA

Pin Description

  • Pin 4 -
  • Pin 5 -
  • Pin 6 - X60003.52 - Secondary Air Pump Valve
  • Pin 7 - X60004.29 - A/C Compressor Relay
  • Pin 14 -
  • Pin 15 - X60004.18 - Exhaust Flap Valve
  • Pin 16 -
  • Pin 17 -

13. Motorola MC33186DH H-Bridge

Motorola MC33186DH H-Bridge Driver IC for the DBW system. File:Motorola MC33186.pdf

Chip Markings
MC33186DH
1
KKER0107

Pin Description

  • Pin 6 - X60003.43 - Electric Throttle Body Actuator 1
  • Pin 7 - X60003.43 - Electric Throttle Body Actuator 1
  • Pin 14 - X60003.44 - Electric Throttle Body Actuator 2
  • Pin 15 - X60003.44 - Electric Throttle Body Actuator 2

14. Motorola TY94084FB Output Stage

Motorola TY94084FB HSOP20 Output Stage for fuel injectors.

A suitable 1:1 replacement seems to be the NXP MC33385: File:NXP MC33385.pdf

Chip Markings
TY94084FBB
ATM36 2.0
96.67.83
KKDP0103

Pin Description

  • Pin 2 - X60003.33 - Fuel Injector Cylinder 1
  • Pin 9 - X60004.17 - Engine Speed Signal
  • Pin 12 - X60003.35 - Fuel Injector Cylinder 3
  • Pin 19 - X60003.34 - Fuel Injector Cylinder 2

15. Motorola TY94084FB Output Stage

Motorola TY94084FBB HSOP20 Output Stage for fuel injectors.

A suitable 1:1 replacement seems to be the NXP MC33385: File:NXP MC33385.pdf

Chip Markings
TY94084FB
ATM36 2.0
96.67.83
KKDP0103

Pin Description

  • Pin 2 - X60003.36 - Fuel Injector Cylinder 4
  • Pin 9 - X60003.42 - Fuel Tank Vent Valve
  • Pin 12 - X60003.38 - Fuel Injector Cylinder 6
  • Pin 19 - X60003.37 - Fuel Injector Cylinder 5

16. ST ATM38E Octal Channel Low-Side Switch

Chip Markings
ATM38E-BD8035
446776
199150113
MALAYSIA

Pin Description

  • Pin 2 - X60002.19 - O2 Sensor Heater Post-Cat Bank 2
  • Pin 9 - X60003.46 - Idle Speed Actuator Closing Coil
  • Pin 12 - X60003.47 - Idle Speed Actuator Opening Coil
  • Pin 19 - X60002.13 - O2 Sensor Heater Pre-Cat Bank 2

17. ST ATM38E Octal Channel Low-Side Switch

Chip Markings
ATM38E-BD8035
446776
199150113
MALAYSIA

Pin Description

  • Pin 2 - X60002.1 - O2 Sensor Heater Pre-Cat Bank 1
  • Pin 9 - X60003.40 - VANOS Intake Solenoid
  • Pin 12 - X60003.41 - VANOS Exhaust Solenoid
  • Pin 19 - X60002.7 - O2 Sensor Heater Post-Cat Bank 1

18. Infineon A2C10025 Voltage Regulator

Infineon A2C10025 Triple Voltage Regulator for 5V supply voltage Similar IC:File:Infineon A2C20219.pdf

Chip Markings
Infineon
A2C10025
ATIC 17C1

Pin Description

  • Pin 2 - 5V, 100 mA, ±0.5% Tracking
  • Pin 9 - 5V, 450 mA, ±2%
  • Pin 17 - 5V, 50 mA, ±0.5% Tracking

Back Side

Siemens MS43 PCB Back.png

1. ZMD U62H64SA SRAM

Automotive Fast 8K x 8 SRAM File:ZMD U62H64SA.pdf

Chip Markings
ZMD
U62H64SA
35 0102

2. Philips 74HCT574

Octal D-type flip-flop File:Philips 74HCT574D.pdf

Chip Markings
74HCT574D
D9524ME
Hnn0105 F

3. Motorola TY93065D

Automotive ISO 9141 Serial Link Driver

Seems to be the same as NXP MC33199D File:NXP MC33199.pdf

Chip Markings
TY93065D
XAA101

4. NXP PCA82C250

CAN Controller Interface File:NXP PCA82C250.pdf

Chip Markings
A82C250
0M6D6
n1064

5. Infineon K-IC 766707

Knock Control IC used to filter the signal coming from knock sensors.

Chip Markings
Infineon
K-IC
766707
VB107092